Numerical Investigation of Flow Hydrodynamics in a Flow Field and Porous Substrate Configuration for Redox Flow Battery Application

Jump To References Section

Authors

  • Rakesh Basavegowda Krishnappa
     Department of Mechanical Engineering, Jyothy Institute of Technology, Bengaluru - 560082, Karnataka ,IN
  • S. Gowreesh Subramanya
     Department of Mechanical Engineering, JSS Academy of Technical Education, Bengaluru - 560060, Karnataka ,IN
  • Abhijit Deshpande
     Domain Expert, Powertrain CFD, Mercedes-Benz RD India, Bengaluru-560066, Karnataka ,IN

DOI:

https://doi.org/10.18311/jmmf/2023/36129

Keywords:

All Iron Redox Flow Battery, Compression Ratio, Computational Fluid Dynamics, Cross-Split Serpentine Flow Field, Permeability, Pressure Drop, Uniformity Index

Abstract

In the recent past, most of the literature reported that the electrolyte circulations in parallel flow field configurations exhibit severe non-uniformity with higher Pressure Drop (Δp). The present work proposes a three-dimensional computational design of flow field configurations to achieve a single-phase uniform flow with minimal pump power and flow dispersion over an active cell area of 131cm2 for All Iron Redox Flow Battery (AIRFB). Computational investigation of the Pressure Drop (Δp), electrolyte flow velocity and uniform flow distribution in the channels and through the graphite felt electrode under various flow conditions was conducted using the Computational Fluid Dynamics (CFD) tool. It is observed from the results that the Multi-Channel Serpentine Flow Field (MCSFF) has the least pressure drop among the other flow fields. However, the Cross-Split Serpentine Flow Field (CSSFF) resulted in better flow circulation and dispersion over the entire active cell area with a high uniformity index, operating at a wide range of flow rates with a reasonable Pressure Drop (Δp). The porous media permeability and a strong function of Compression Ratio (CR) were numerically validated from the well-known correlation existing in the literature. At CR 50% it was observed that the volume uniformity index of the felt was 69%, which would correspondingly enhance the rate of mass transfer and electro-kinetics at electrode felt and ion conductivity across the membrane. The CSSFF configuration is predominant in terms of uniform flow distribution and wettability at the defined operating conditions resulting in enhanced cell performance.

Downloads

Download data is not yet available.

Metrics

Metrics Loading ...

Downloads

Published

2023-12-01

How to Cite

Krishnappa, R. B., Gowreesh Subramanya, S., & Deshpande, A. (2023). Numerical Investigation of Flow Hydrodynamics in a Flow Field and Porous Substrate Configuration for Redox Flow Battery Application. Journal of Mines, Metals and Fuels, 71(12), 2493–2511. https://doi.org/10.18311/jmmf/2023/36129

Issue

Volume 71, Issue 12, December 2023

Section

Articles

License

Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

Crossref
Scopus
Google Scholar
Europe PMC
Received 2024-01-08
Accepted 2024-02-01
Published 2023-12-01

 

References

Zhengqui Y, Jianlu Z, Michael CW, Kintner-Meyer, Xiaochuan L, Daiwon C, John P, Lemmon, Jun L. Electrochemical energy storage for the green grid. Chemical Reviews: ACS Publications. 2011; 111:3577-613. https://doi.org/10.1021/cr100290v. PMid:21375330. DOI: https://doi.org/10.1021/cr100290v

Zhenguo Y, Yun L, Suresh B, Carl H I, Jamie DH. Enabling renewable energy and future grid - with advanced electricity storage. Energy Storage Technologies. 2010; 62:14-23. https://doi.org/10.1007/s11837-010-0129-0. DOI: https://doi.org/10.1007/s11837-010-0129-0

Piergiorgio A, Massimo G, Federico M. Redox flow batteries for the storage of renewable energy: A review. Renewable and Sustainable Energy Reviews. 2014; 29:325-35. https://doi.org/10.1016/j.rser.2013.08.001. DOI: https://doi.org/10.1016/j.rser.2013.08.001

Narendra MK, Manoj Kumar S, Vijayakumar GC, Kadirgama K, Samykano M, Krishna Venkatesh, Murlidhara HB. Effect of flow field geometry on hydrodynamics of flow in redox flow battery. Energy Engineering, Tech Science Press. 2022; 119:201-17. https://doi.org/10.32604/EE.2022.016597. DOI: https://doi.org/10.32604/EE.2022.016597

Luis FA, Carlos Ponce de León, Frank Walsh C. Redox flow batteries for energy storage: Their promise, achievements and challenges. Current Opinion in Electrochemistry. 2019; 16:117-26. https://doi.org/10.1016/j.coelec.2019.05.007. DOI: https://doi.org/10.1016/j.coelec.2019.05.007

Bruce D, Haresh K, Jean-Marie T. Electrical energy storage for the grid: A battery of choices. Materials for grid energy. Science AAAS. 2011; 334(6058):928-35. https://doi.org/10.1126/science.1212741. PMid:22096188. DOI: https://doi.org/10.1126/science.1212741

Arenas LF, Ponce de León C, Walsh FC. Engineering aspects of the design, construction and performance of modular redox flow batteries for energy storage. Journal of Energy Storage. 2017; 11:119-53. https://doi.org/10.1016/j.est.2017.02.007. DOI: https://doi.org/10.1016/j.est.2017.02.007

Skyllas-Kazacos M, Chakrabarti MH, Hajimolana SA, Mjalli FS, Saleem M. Progress in flow battery research and development. Journal of the Electrochemical Society. 2011; 158(8):55-79. https://doi.org/10.1149/1.3599565. DOI: https://doi.org/10.1149/1.3599565

Michael Gerhardt R, Andrew Wong A, Michael JA. The effect of interdigitated channel and land dimensions on flow cell performance. Journal of the Electrochemical Society. 2018; 165(11):2625-43. https://doi.org/10.1149/2.0471811jes. DOI: https://doi.org/10.1149/2.0471811jes

Kumar S, Jayanti S. Effect of electrode intrusion on pressure drop and electrochemical performance of an all-vanadium redox flow battery. Journal of Power Sources. 2017; 360: 548-58. https://doi.org/10.1016/j.jpowsour.2017.06.045. DOI: https://doi.org/10.1016/j.jpowsour.2017.06.045

Gundlapalli R, Jayanti S. Effect of channel dimensions of serpentine flow fields on the performance of a vanadium redox flow battery. Journal of Energy Storage. 2019; 23:148-58. https://doi.org/10.1016/j.est.2019.03.014. DOI: https://doi.org/10.1016/j.est.2019.03.014

Kumar S, Jayanti S. Effect of flow field on the performance of an all-vanadium redox flow battery. Journal of Power Sources. 2016; 307:782-87. https://doi.org/10.1016/j.jpowsour.2016.01.048. DOI: https://doi.org/10.1016/j.jpowsour.2016.01.048

Gundlapalli R, Jayanti S. Effective splitting of serpentine flow field for applications in large-scale flow batteries. Journal of Power Sources. 2021; 487:229409. https://doi.org/10.1016/j.jpowsour.2020.229409. DOI: https://doi.org/10.1016/j.jpowsour.2020.229409

T Jyothi L, Jayanti S. Ex-situ experimental studies on serpentine flow field design for redox flow battery systems. Journal of Power Sources. 2014; 248:140-6. https://doi.org/10.1016/j.jpowsour.2013.09.084. DOI: https://doi.org/10.1016/j.jpowsour.2013.09.084

Maharudrayya S, Jayanti S, Deshpande AP. Flow distribution and pressure drop in parallel-channel configurations of planar fuel cells. Journal of Power Sources. 2005; 144:94-106. https://doi.org/10.1016/j.jpowsour.2004.12.018. DOI: https://doi.org/10.1016/j.jpowsour.2004.12.018

T. Jyothi L, Jayanti S. Hydrodynamic analysis of flow fields for redox flow battery applications. Journal of Applied Electrochemistry. 2014; 44:995-1006. https://doi.org/10.1007/s10800-014-0720-0. DOI: https://doi.org/10.1007/s10800-014-0720-0

S. Kumara T, Jyothi L, Jayanti S. Experimental studies of permeability measurement and hydrodynamics study of all-vanadium redox flow battery. Materials Today: Proceedings. 2018; 5:23169-76. https://doi.org/10.1016/j.matpr.2018.11.048. DOI: https://doi.org/10.1016/j.matpr.2018.11.048

Dennison CR, Ertan Agar, Bilen Akuzum, Kumbura EC. Enhancing mass transport in redox flow batteries by tailoring flow field and electrode design. Journal of the Electrochemical Society. 2016; 163(1):5163-69. https://doi.org/10.1149/2.0231601jes. DOI: https://doi.org/10.1149/2.0231601jes

Xu Q, Zhao TS, Leung PK. Numerical investigations of flow field designs for vanadium redox flow batteries. Applied Energy. 2013; 105:47-56. https://doi.org/10.1016/j.apenergy.2012.12.041. DOI: https://doi.org/10.1016/j.apenergy.2012.12.041

Rober JK, Pavan K, Kevin W, Mark P. A generalized model of the flow distribution in channel networks of planar fuel cells. Journal of Power Sources. 2002; 109(1):148-59. https://doi.org/10.1016/S0378-7753(02)00090-3. DOI: https://doi.org/10.1016/S0378-7753(02)00090-3

Xianguo L, Imran S. Review of bipolar plates in PEM fuel cells: Flow-field designs. International Journal of Hydrogen Energy. 2005; 30(4):359-71. https://doi.org/10.1016/j.ijhydene.2004.09.019. DOI: https://doi.org/10.1016/j.ijhydene.2004.09.019

Bo-Ra K, Deok-Young S, Yun-Ho C, Yong-Hee L. A study on flow characteristics and flow uniformity for the efficient design of a flow frame in a redox flow battery. Applied Sciences MDPI. 2020; 10:929. https://doi.org/10.3390/app10030929. DOI: https://doi.org/10.3390/app10030929

Gundlapalli R, Jayanti S. Performance characteristics of several variants of interdigitated flow fields for flow battery applications. Journal of Power Sources. 2020; 467:228225. https://doi.org/10.1016/j.jpowsour.2020.228225. DOI: https://doi.org/10.1016/j.jpowsour.2020.228225

Xu Q, Zhao TS, Zhang C. Performance of a vanadium redox flow battery with and without flow field. Electrochimica Acta. 2014; 142:61-7. https://doi.org/10.1016/j.electacta.2014.07.059. DOI: https://doi.org/10.1016/j.electacta.2014.07.059

Maharudrayya S, Jayanti S, Deshpande AP. Pressure losses in laminar flow through serpentine channels in fuel cell stacks. Journal of Power Sources. 2004; 38:1-13. https://doi.org/10.1016/j.jpowsour.2004.06.025. DOI: https://doi.org/10.1016/j.jpowsour.2004.06.025

Xinyou K, Joseph MP, J. Iwan D, Alexander, Robert FS. Redox flow batteries with serpentine flow fields: Distributions of electrolyte flow reactant penetration into the porous carbon electrodes and effects on performance. Journal of Power Sources. 2018; 384:295-302. https://doi.org/10.1016/j.jpowsour.2018.03.001. DOI: https://doi.org/10.1016/j.jpowsour.2018.03.001

Xinyou K, Joseph M.P, J. Iwan D, Alexander, Jesse SW, Thomas Zawodzinski A, Robert FS. Rechargeable redox flow batteries: Flow fields, stacks and design considerations. Chemical Society Reviews. 2018; 47(23):8721-43. https://doi.org/10.1039/C8CS00072G. PMid:30298880. DOI: https://doi.org/10.1039/C8CS00072G

Prumbohm E, Becker M, Flaischlen S, Wehinger GD, Turek T. Flow field designs developed by comprehensive CFD model decrease system costs of vanadium redox-flow batteries. Journal of Flow Chemistry. 2021; 11:461-81. https://doi.org/10.1007/s41981-021-00165-2. DOI: https://doi.org/10.1007/s41981-021-00165-2

Qiong Z, Feng X, Xianfeng L, Guiling N, Huamin Z. Flow field design and optimisation based on the mass transport polarisation regulation in a flow-through type vanadium flow battery. Journal of Power Sources. 2016; 324:402-11. https://doi.org/10.1016/j.jpowsour.2016.05.110. DOI: https://doi.org/10.1016/j.jpowsour.2016.05.110

Heledd J, Natalia Y. Corporate social responsibility in the mining industry: Exploring trends in social and environmental disclosure. Journal of Cleaner Production. 2006; 14:271-84. https://doi.org/10.1016/j.jclepro.2004.10.004. DOI: https://doi.org/10.1016/j.jclepro.2004.10.004

Norgate T, Haque N. Energy and greenhouse gas impacts of mining and mineral processing operations. Journal of Cleaner Production. 2010; 18:266-74. https://doi.org/10.1016/j.jclepro.2009.09.020. DOI: https://doi.org/10.1016/j.jclepro.2009.09.020

Michelle L, Dean M, Jacek P. Energy and mining e the home truths. Journal of Cleaner Production. 2014; 1:1-23.

Tsisilile I, Kwame A, Alexandra N, Travis L, Jill EC. Integrating renewable energy into mining operations: Opportunities, challenges, and enabling approaches. Applied Energy. 2021; 300:117375. https://doi.org/10.1016/j.apenergy.2021.117375. DOI: https://doi.org/10.1016/j.apenergy.2021.117375

Tamayol A, McGregor, Bahrami FM. Single phase through-plane permeability of carbon paper gas diffusion layers. Journal of Power Sources. 2012; 204:94-9. https://doi.org/10.1016/j.jpowsour.2011.11.084. DOI: https://doi.org/10.1016/j.jpowsour.2011.11.084

Anarghya D, Anantha MS, Venkatesh K, Santosh MS, Geetha Priya M, Muralidhara HB. Bermuda grass-derived nitrogen-doped carbon as electrocatalyst in graphite felt electrode to increase the efficiency of alliron redox flow batteries. Journal of Electroanalytical Chemistry. 2020; 878:114577. https://doi.org/10.1016/j.jelechem.2020.114577. DOI: https://doi.org/10.1016/j.jelechem.2020.114577

Tenhumberg. Kinetic studies at carbon felt electrodes for vanadium redox-flow batteries under controller transfer current density conditions. Electrochim Acta. 2017; 252:12-24. https://doi.org/10.1016/j.electacta.2017.07.062. DOI: https://doi.org/10.1016/j.electacta.2017.07.062

White FM. Fluid Mechanics. McGraw Hill.Inc, University of Rhode Island; 1994.

Bortolin S, Toninelli P, Maggiolo D, Guarnieri M, Del Col D. CFD study on electrolyte distribution in redox flow batteries. Journal of Physics: Heat transfer Conference. 2015; 655:012049. https://doi.org/10.1088/1742-6596/655/1/012049. DOI: https://doi.org/10.1088/1742-6596/655/1/012049

Afshin G, Peter R. PIV-Measurements of centrifugal instabilities in a rectangular curved duct with a small aspect ratio. Fluids, MDPI. 2021; 6(5):184. https://doi.org/10.3390/fluids6050184. DOI: https://doi.org/10.3390/fluids6050184